99 KTM 300 EXC Ignition Problem - No Spark?
Posted: Fri Nov 15, 2013 1:18 pm
Bucho's 99 300 EXC started (after sitting for a month) and was then ridden several miles to my house for a minor tail light wire repair.
After shutting it off and us fixing the tail light wire it wouldn't start.
There is no spark. I have disconnected all the various connectors and then did a ground continuity test of each of the 5 the stator wires to ground and got no continuity on any except the Yellow female spade connector which is a full ground (zero OHMS)
I then tested continuity between each possible pair of wires and found no continuity between any pair except the pair that are in a male/female 2 part connector which showed a little over 2 OHMS.
Are these test results NORMAL? Or does this indicate a stator problem?
ANY advice or comments welcome!
I already did trim a little off of the coil/plug wire and changed to a new plug but still NO JOY
The parts book shows the stator to be a 54739004100 STATOR KOKUSAN 2K-2 '97
The list of wires from the stator is:
Yellow - Female Spade
Red - Male single pin
Green - Female single pin
Red with White Stripe - Male part of 2 part connector
Black with Red Stripe - Female part of 2 part connector
After shutting it off and us fixing the tail light wire it wouldn't start.
There is no spark. I have disconnected all the various connectors and then did a ground continuity test of each of the 5 the stator wires to ground and got no continuity on any except the Yellow female spade connector which is a full ground (zero OHMS)
I then tested continuity between each possible pair of wires and found no continuity between any pair except the pair that are in a male/female 2 part connector which showed a little over 2 OHMS.
Are these test results NORMAL? Or does this indicate a stator problem?
ANY advice or comments welcome!
I already did trim a little off of the coil/plug wire and changed to a new plug but still NO JOY
The parts book shows the stator to be a 54739004100 STATOR KOKUSAN 2K-2 '97
The list of wires from the stator is:
Yellow - Female Spade
Red - Male single pin
Green - Female single pin
Red with White Stripe - Male part of 2 part connector
Black with Red Stripe - Female part of 2 part connector